Service of IZh 2126
1. General information
2. Engine UEPA-331
3. VAZ-2106 engine
4. Cooling system
5. Power supply system
6. Carburetor
7. System of ignition of the engine UEPA-331
8. System of ignition of the VAZ-2106 engine
9. System of production of the fulfilled gases
10. Coupling
11. IZh-2126 transmission
12. VAZ-21074 transmission
13. Cardan transfer
14. Zadny Bridge
15. Forward suspension bracket
16. Back suspension bracket
17. Steering
18. Brake system
19. Electric equipment
20. Body
21. System of ventilation and heating
21.1. Description of a design
21.2. Removal of the crane of a heater
21.3. Removal of the airsupercharger and fan of a heater
21.4. Removal of the additional resistor of the fan of a heater
21.5. Removal of a radiator of a heater
21.6. Removal of the case of a heater, control unit of a heater and air ducts of the dashboard
21.7. Removal of an air duct of air supply in a back part of salon
22. Features of a design of the IZh-2717 car
23. Appendix
24. Care of a car body
 










21-1-opisanie-konstrukcii.html

21.1. Description of a design

System of ventilation and heating: 1 - left deflector; 2 - left side air duct; 3 - central air duct; 4 - central deflectors; 5 - heater case; 6 - top gate of a heater; 7 - heater radiator; 8 - voedukhonagnetatel; 9 - right side air duct; 10 - right deflector; 11 - lower gate of a heater; 12 - an air supply air duct in a back part of salon; 13 - draft of control of the top gate of a heater; 14 - control unit otopitvly; 15 - draft of control of the lower gate of a heater; I - cold air; II - the warmed-up air; III - a supply of hot liquid to a heater radiator; IV - removal of liquid from a heater radiator

Description of a design

System of ventilation forced-air and exhaust. At the movement of the car air is forced in salon by a natural pressure through a crack between a cowl and a windshield. For increase in air supply it is possible to lower glasses of doors, and at a low speed to turn on the electric fan air of the supercharger located in a motor compartment.

The fan electric motor collector, a direct current, with excitement from permanent magnets. Frequency of rotation of the fan is regulated by the four-position switch on the dashboard. Depending on the chosen speed the electric motor is connected to onboard network of the car directly or via the additional resistor. The last has two spirals with a resistance of 0,23 Ohms and 0,82 Ohms. If in both spirals are included, the fan rotates at a small speed if only one (0,23 Ohms) on average. The fan connected directly rotates with the maximum speed. Frequency of rotation of a shaft of the electric motor with a krylchatka at a voltage of 12 V and the air temperature of (25+10) C 4100200 min.-1. The consumed current with the maximum frequency of rotation no more than 14 And.

The electric motor is not subject to repair (behind an exception a collector), at failure it should be replaced assembled with a fan wheel. It is not recommended to press a fan wheel from an electric motor shaft it is possible to break its balancing.

Air streams in salon are distributed by the air ducts located in the dashboard and in a floor casing. On a windshield air arrives through the top slit-like nozzles on the dashboard, on side glasses via the left and right deflectors.

To legs of the driver and forward passenger air arrives through openings in the lower part of the case of a heater, and to legs of back passengers through an air duct in a floor casing.

For management of distribution of air streams the top lever of the control unit located on the dashboard consoles and also directing the central and side deflectors and their regulators serves. The top lever on the central console operates position of the lower gate of a heater, regulating air supply to legs.

System of heating liquid, integrated with the engine cooling system. The radiator of a heater is installed in the case located in interior of the car under the dashboard. Supply of liquid to a radiator is regulated the heater crane located in a motor compartment on the taking-away heater hose. Control of the crane manual of a motor compartment.

The air arriving from the airsupercharger can pass through a radiator of a heater or passing it, depending on position of the top gate of a heater operated by the lower lever on the dashboard console.


"previous page
21. System of ventilation and heating
following page"
21.2. Removal of the crane of a heater